MSDS 1901
MATERIAL SAFETY DATA SHEET
11/15/07 ESSENTIALLY SIMILAR TO U.S. DEPARTMENT OF LABOR FORM OSHA-174
SECTION I-IDENTIFICATION
MANUFACTURER NAME: SCOTCH CORPORATION
ADDRESS: 1303 CHEMICAL ST, DALLAS, TEXAS 75207
EMERGENCY TELEPHONE NO.: 214-943-4605
TRADE NAME: INSTANT POWER BUILD-UP REMOVER
PRODUCT CODE: 1901
SECTION II-HAZARDOUS INGREDIENTS
(THE HAZARDS PRESENTED BELOW ARE THOSE OF THE INDIVIDUAL COMPONENTS.
HAZARDOUS COMPONENTS: CAS # OSHA PEL ACGIH TLV HZD TYPE
UREA 57-13-6 10MG/M3 5MG/M3 TOX/IRR
SODIUM CHLORIDE 7647-14-5 15MG/M3 10MG/M3 NUIS.DUST
SODIUM BICARBONATE 144-55-8 15MG/M3 10MG/M3 NUIS.DUST
MONOSODIUM PHOSPHATE 75558-80-7 N/A NA NUIS.DUST
SODIUM THIOSULFATE 7772-98-7 N/A N/A IRRITANT
NONYLPHENOXY POLYETHOXYETHANOL 26027-38-3 N/A N/A IRR/SLIGHT TOXIC
CALCIUM SULFATE DIHYDRATE 10101-41-4 15MG/M3 10MG/M3 NUIS.DUST
SECTION III-PHYSICAL DATA SECTION IV-FIRE AND EXPLOSION HAZARD DATA
BOILING POINT: N/A FLASH POINT (METHOD USED): NON-FLAMMABLE
SPECIFIC GRAVITY (H20=1): N/A FLAMMABLE LIMITS: N/A
VAPOR PRESSURE (MM HG): <1 LEL: N/A UEL: N/A
MELTING POINT: N/A EXTINGUISHING MEDIA: FOAM, ALCOHOL FOAM CO2, DRY CHEMICAL
VAPOR DENSITY (AIR=1): N/A WATER SPRAY.
COLOR & ODOR: TAN WITH A YEAST ODOR SPECIAL FIRE FIGHTING PROCEDURES: CHOOSE EXTINGUISHING MEDIA
EVAPORATION RATE (BUTYL ACETATE=1): N/A BASED ON SURROUNDING FIRE. IN ALL FIRES INVOLVING CHEMICALS,
PH @ 100%: 7.5 WEAR SELF-CONTAINED BREATHING APPARATUS AND PROTECTIVE
VISCOSITY: POWDER CLOTHING.
SOLUBILITY IN WATER: APPRECIABLE UNUSUAL FIRE AND EXPLOSION HAZARDS: N/A
APPEARANCE: OPAQUE NFPA HAZARD RATING (O=INSIGNIFICANT; 1-SLIGHT; 2=MODERATE;
3=HIGH; 4=EXTREME):
1 HEALTH; 1 FLAMMABILITY; 0 REACTIVITY; N/A SPECIAL
SECTION V-HEALTH HAZARD DATA
CARCINOGEN:
NTP: NO IARC MONOGRAPHS: NO OSHA: NO
HEALTH HAZARDS (ACUTE AND CHRONIC): ACUTE-INHALATION: DUST MAY CAUSE IRRITATION OF THE NOSE, THROAT AND LUNGS.
MAY ALSO CAUSE COUGHING AND SNEEZING. EYES: MAY CAUSE IRRITATION AND WATERING OF THE EYES. SKIN: MAY CAUSE MILD
IRRITATION. INGESTION: MAY CAUSE NAUSEA. CHRONIC-INGESTION OF LARGE AMOUNTS MAY PRODUCE NAUSEA AND VOMITING.
DIRECT CONTACT OVER A LONG PERIOD OF TIME MAY CAUSE CORNEAL DAMAGE OR DERMATITIS.
EMERGENCY FIRST AID PROCEDURES: INHALATION-REMOVE FROM AREA TO FRESH AIR. SEEK MEDICAL ATTENTION IF IRRITATION
PERSISTS OR IF BREATHING BECOMES DIFFICULT. EYE CONTACT-FLUSH EYES WITH WATER FOR SEVERAL MINUTES. IF IRRITATION
PERSISTS SEE PHYSICIAN. SKIN CONTACT-WASH AREA WITH SOAP AND WATER. KEEP OUT OF OPEN CUTS OR SORES. IF IRRITATION
PERSISTS, SEE A PHYSICIAN. INGESTION-GIVE 3-4 GLASSES OF WATER AND INDUCE VOMITING BY PLACING A FINGER OR BLUNT
OBJECT ON THE BACK OF THE VICTIM'S TONGUE. GIVE FLUIDS UNTIL VOMITUS IS CLEAR. NEVER INDUCE VOMITING OR GIVE ANYTHING
BY MOUTH TO AN UNCONSCIOUS OR CONVULSING PERSON. SEEK MEDICAL ATTENTION.
PAGE 1 OF 3
SCOTCH CORPORATION PRODUCT CODE 1901
SECTION VI-REACTIVITY DATA
STABILITY: STABLE
CONDITIONS TO AVOID: N/A
IMCOMPATIBILITY (MATERIAL TO AVOID): DISINFECTANTS, STRONG ACIDS OR BASES.
HAZARDOUS DECOMPOSITION OR BYPRODUCTS: OXIDES OF CARBON, OXIDES OF SULFUR, SODIUM SULFIDE.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
SECTION VII-SPILL OR LEAK PROCEDURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: SWEEP UP SPILLED MATERIAL FOR DISPOSAL OR REUSE. AVOID
CREATING DUST. FLUSH AREA WITH WATER TO REMOVE RESIDUE.
WASTE DISPOSAL METHOD: DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE, AND LOCAL REGULATIONS. THE PRODUCT MAY BE
DISPOSED OF DOWN THE DRAIN.
STORAGE TEMPERATURE: 120 F MAX 2 F MIN; INDOOR
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING: STORE IN A TIGHTLY CLOSED CONTAINER IN A COOL, DRY AREA. WASH
THOROUGHLY AFTER HANDLING.
OTHER PRECAUTIONS: KEEP OUT OF REACH OF CHILDREN. READ ENTIRE LABEL BEFORE USING THIS PRODUCT.
SECTION VIII-SPECIAL PROTECTION INFORMATION
RESPIRATORY PROTECTION: TYPICAL USE OF THIS PRODUCT DOES NOT REQUIRE A SPECIAL RESPIRATOR. IN AREAS OF
EXCESSIVELY HIGH DUST, WEAR A NIOSH/MSHA APPROVED RESPIRATOR.
VENTILATION REQUIRED: NONE USUALLY REQUIRED WITH THIS PRODUCT.
PROTECTIVE GLOVES: NEOPRENE RUBBER GLOVES
EYE PROTECTION: SAFETY GLASSES WITH SIDE SHIELDS.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT: N/A
WORK/HYGIENIC PRACTICES: N/A
SECTION IX-TOXICITY INFORMATION
UREA: SODIUM THIOSULFATE:
ORL-RAT LD50: 800 MG/KG 3. SCU-RBT LDLO: 4000 MG/KG 3.
EYE-RBT 750MG SEV 3. SCU-FRG LDLO: 6000 MG/KG 3.
MUT-MMO DATA- SAT 1OUL/PLATE 3. MONOSODIUM PHOSPHATE:
SODIUM CHLORIDE: ORL-RAT LD50: 8290 MG/KG 3.
ORL-RAT LD50: 3750 MG/KG 4. EYE-RBT 150 MG MLD 3.
EYE-RBT 100MG/24H MOD 3. EYE HMN 50 MG MLD 3.
SKN-RBT 50MG/24H MLD 3. CALCIUM SULFATE DIHYDRATE:
SODIUM BICARBONATE: IHL-HMN TOLO: 194G/M3/10Y-I 3.
ORL-RAT LD50: 4220 MG/KG 4.
SKN-RBT 30MG/3D MLD 4. NONYLPHENOXY POLYETHOXYETHANOL:
ORL-RAT LD50: 2210 MG/KG 4.
SKN-RBT LD50: >2 G/KG 4.
EYE-RBT SEV
SECTION X-REGULATORY INFORMATION
CHEMICAL NAME: N/A C.A.S. NUMBER : UPPER % LIMIT:
THOSE INGREDIENT LISTED ABOVE ARE SUBJECT TO THE REPORTING REQUIREMENTS OF 313 OF TITLE III OF THE SUPERFUND
AMENDMENTS AND REAUTHORIZATION ACT OF 1986 AND 40 CFR PART 372.
IF UE (USE EXEMPTION) APPEARS BESIDE UPPER % LIMIT, END USERS ARE EXEMPT FROM NOTIFICATION BECAUSE THE
PRODUCT IS USED AND LABELED FOR ROUTINE JANITORIAL WORK, OR THE PRODUCT IS USED AND LABELED FOR FACILITY GROUNDS
MAINTENANCE (SUCK AS FERTILIZERS AND HERBICIDES), OR THE PRODUCT IS USED AND LABELED FOR MAINTAINING MOTOR
VEHICLES.
PAGE 2 OF 3
SCOTCH CORPORATION PRODUCT CODE 1901
CALIFORNIA PROPOSITION 65:
WARNING: THIS PRODUCT CONTAINS THE FOLLOWING CHEMICAL(S) KNOWN TO THE STATE OF CALIFORNIA TO CAUSE (1) CANCER OR
(2) BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM:
ETHYLENE OXIDE ( ), 1,4-DIOXANE (1), FORMALDEHYDE (1) AND ACETALDEHYDE (1) AS TRACE CONTAMINANTS.
THE INFORMATION CONTAINED HEREIN IS BASED ON DATA CONSIDERED ACCURATE IN LIGHT OR CURRENT FORMULATION, HOWEVER,
NO WARRANTY IS EXPRESSED OR IMPLIED REGARDING THE ACCURACY OF THIS DATA OR THE RESULTS TO BE OBTAINED FROM THE
USE THEREOF.
SCOTCH CORPORATION ASSUMES NO RESPONSIBILITY FOR PERSONAL INJURY OR PROPERTY DAMAGE CAUSED BY THE USE,
STORAGE OR DISPOSAL OF THE PRODUCT IN A MANNER NOT RECOMMENDED ON THE PRODUCT LABEL. USERS ASSUME ALL RISKS
ASSOCIATED WITH SUCH UNRECOMMENDED USE, STORAGE, OR DISPOSAL OF THE PRODUCT.
PAGE 3 OF 3
|